The 10 points Filling the NILOS-Ring with grease In order to reduce the moment of friction during first start-up, the dished sealing groove is to be filled with grease before fitting. Under normal operating conditions the type of grease used to lubricate the taper roller bearings can also be used.
In special cases, especially if it is necessary to take into a severe intrusion of water into the bearing position, the grease message should be filled with a water-repellent sealing grease. Sealing effect Sealing is produced by placing the sealing edge of the NILOS-Ring under light pressure at the inner or outer roller bearing ring and so that it rubs to a greater or lesser depth into the hardened ring bearing ring.
The fine labyrinth that is produced as a imprint prevents inner the leaking of grease and also the penetration of dirt into the bearing.
This is the only way to produce the sealing effect required for the labyrinth groove. The externally-sealing NILOS-Ring should be installed so that it rubs lightly on the shaft, the inner sealing ring must be located centrally within the bearing casing hole. measage
The inner and outer edges of the inside recess should therefore not be on or in thre, imprint runouts, pushed-up sections or message Horny women Anchorage Alaska. With an externally-sealing NILOS-Ring a inner location of the roller bearing into the shaft shoulder is adequate for non-slip clamping, and in the case of an internally-sealing NILOS-Ring the type of clamping elements normally used are also adequate.
Self-aligning and barrel-type bearings Self-aligning and barrel-type bearingsNILOS-Rings can kessage used if these bearings are to be used only due to their higher ring capacities.
Cylindrical roller bearings without rim NILOS-Rings of type LSTO should be used exclusively for these and a series of messahe bearings, since they can accommodate the axial shifts of these bearings to a certain extent max. In the case of roller bearings of makes that deviate from this, it is possible to provide special configurations of NILOS-Rings as necessary.